SureTrack Community Fix: Buzzin’ in your Escalade
Real Fixes from Mitchell 1’s SureTrack® expert information resource are documented issues from actual shop repair orders and community discussions. Read on to see how SureTrack can help you correct issues that are not easily diagnosed using OEM information alone. SureTrack is available at no additional cost in our ProDemand product.
Here’s another case of a hard to diagnose noise that only happens while driving. SureTrack community member Jeffytune had a Cadillac Escalade in the shop with a buzzing noise happening after driving over a bump or dip. Not only that, the noise stop happening after it warmed up. They posed the question to the community, and with the help of fellow community members ericsautomotive and jbsprintcar, they were able to resolve the issue quickly.
The following Community Fix summarizes the interaction between members of the community that led to the solution.
2005 Cadillac Escalade ESV 6.0L
Loud noise after driving over bump, repaired axle seal.
Customer complains of loud buzzing sound after driving over a bump or dip.
Diagnostic Steps Performed/Parts Replaced
In driving the vehicle (more often when first started cold) and you drive over a bump or dip, the vehicle will very loudly buzz. More so at slow speeds. We can not get it to do it in the shop on the lift, it has to be moving. From the driver seat, it sounds like it was from the left front, when walking next to the vehicle, it seems to be more in the left rear. We first thought it might be the ABS pump, we unplugged both the pre pump and the main ABS units, it still does it. We then thought it could be the air ride compressor, we unplugged it and still the same. We first tried to remove the fuses to the ABS and the air ride, then we physically unplugged them, and still no change. After the vehicle is driven enough to warm it up, this issue stops. When it does it, it is loud and buzzes the floor, so it seems like it’s right under your feet. I read the TSB on the wheel bearing issue for the ABS, but with the units (both of them) unplugged, I can not see how they could.
We finally got it to do the noise on the rack by power braking it and hitting the suspension with a rubber hammer. We hit the bottom of the left rear tire, and the buzzing started, then as the tire stopped, the buzzing stopped. We pulled the tire off and the brakes looked fine, we then pulled the rotor off and there was the issue. The axle seal was leaking a small amount of gear oil on to the one piece park brake shoe. You could not see any gear oil on the backing plate (rear disc with the one-piece parking brake shoe) and the shoe was the source of the noise. This explains why as you drove it the noise would go away and it would only do it cold. We replaced the axle seal and shoe, did a clean up in the inner rotor and backing plate, then test drove it, no more noise.
Replaced axle seal and parking brake shoe, vehicle no longer makes buzzing sound.
SureTrack® adds to the power of ProDemand® with an exclusive combination of real-world knowledge and powerful diagnostic tools, all wrapped in an interactive community of professional technicians. Designed to help automotive shops increase accuracy and efficiency from diagnosis to completed repair, the industry’s most comprehensive repair information resource is just a few clicks away.
Want more? Here’s how you can see more Real Fixes in SureTrack: